岩性对砂石加工高浓度废水动态辐流沉降特性的影响

doi:10.11988/ckyyb.20210868

长江科学院院报 ›› 2023, Vol. 40 ›› Issue (2): 75-80.DOI: 10.11988/ckyyb.20210868

岩性对砂石加工高浓度废水动态辐流沉降特性的影响

郭辉^1,2,3, 於思瀚^2,3, 陈雯⁴, 黄明海^2,3, 陈端^1,2,3

1.中南勘测设计研究院有限公司水能资源利用关键技术湖南省重点实验室,长沙 410000;
2.长江科学院水力学研究所,武汉 430010;
3.长江科学院流域水资源与生态环境科学湖北省重点实验室,武汉 430010;
4.长江勘测规划设计研究有限责任公司市政与交通工程设计院,武汉 430010

收稿日期:2021-08-24 修回日期:2021-11-18 出版日期:2023-02-01 发布日期:2023-03-07
通讯作者: 陈端(1978-),男,四川大竹人,正高级工程师,博士,研究方向为生态水力学。E-mail:chenduan@mail.crsri.cn
作者简介:郭辉(1982-),男,安徽霍邱人,正高级工程师,博士研究生,研究方向为生态水利。E-mail:guohui@mail.crsri.cn
基金资助:
水能资源利用关键技术湖南省省重点实验室开放研究基金(PKLHD201705)

Effect of Rock Type on Dynamic Radial-flow Sedimentation Characteristics of High Concentration Wastewater from Processing Aggregate System of Hydropower Project

GUO Hui^1,2,3, YU Si-han^2,3, CHEN Wen⁴, HUANG Ming-hai^2,3, CHEN Duan^1,2,3

1. Hunan Provincial Key Laboratory of Key Technology on Hydropower Development,Zhongnan Engineering Corporation Limited,Changsha 410000,China;
2. Hydraulics Department,Yangtze River Scientific Research Institute,Wuhan 430010,China;
3. Hubei Provincial Key Laboratory of Basin Water Resource and Eco-environmental Sciences,Yangtze River Scientific Research Institute,Wuhan 430010,China;
4. Department of Municipal and Traffic Engineering,Changjiang Institute of Survey,Planning, Design,and Research,Wuhan 430010,China

Received:2021-08-24 Revised:2021-11-18 Online:2023-02-01 Published:2023-03-07

摘要/Abstract

摘要： 为探明岩性对水电工程砂石加工高浓度废水辐流池动态沉降特性的影响,以白鹤滩水电站砂石加工系统废水处理工程辐流池为例,基于动态沉降试验模型律,建立废水动态辐流沉降大比尺物理模型试验,分析以玄武岩和灰岩为料源的砂石骨料加工废水动态辐流沉降规律。试验表明:采用PAM和PAC联合投加可改善废水沉降浓缩效果,出水悬浮物去除率高于99%;玄武岩废水工况下,辐流池中部流速较高,固体颗粒呈现沿水深线性沉降浓缩的去除模式;灰岩废水工况下,辐流池底部流速较高,固体颗粒呈现先沿水深快速沉降,后在底层逐渐浓缩的去除模式;相较于灰岩废水,玄武岩废水自然沉降性能较差,辐流沉淀过程中对排泥速率控制的要求更高。研究成果可为水电工程绿色施工提供技术支撑。

关键词: 水电工程, 砂石系统, 岩性, 高浓度废水, 动态辐流沉降, 物理模型

Abstract: The aim of this study is to investigate the influence of rock type on dynamic radial-flow sedimentation of high concentration wastewater produced from processing aggregate system for hydropower project.On the basis of the scaling law for high concentration wastewater,a large-scale physical model of the radial-flow sedimentation tank of Baihetan Hydropower Project was established as a prototype to elucidate the effect of basalt and limestone on dynamic radial-flow sedimentation characteristics.Experiment results manifested that combined addition of PAM and PAC could improve the settling and thickening effect of wastewater with the removal rate of suspended substance in treated water exceeding 99%.For basalt wastewater,higher velocity was observed in the middle layer of radial-flow sedimentation tank,and solid particles presented linear sedimentation along water depth;for limestone wastewater,higher velocity was observed in the bottom layer of radial-flow sedimentation tank,and solid particles settled rapidly along water depth in the first phase,and then gradually concentrated in the bottom layer.Compared with limestone wastewater,basalt wastewater is of inferior natural sedimentation performance,posing higher control requirement for sludge discharge rate during radial-flow sedimentation.The research findings offer technical support for green construction of hydropower projects.

Key words: hydropower project, aggregate system, rock type, wastewater of high concentration, dynamic radial flow sedimentation, physical model

中图分类号:

TV52

郭辉, 於思瀚, 陈雯, 黄明海, 陈端. 岩性对砂石加工高浓度废水动态辐流沉降特性的影响[J]. 长江科学院院报, 2023, 40(2): 75-80.

GUO Hui, YU Si-han, CHEN Wen, HUANG Ming-hai, CHEN Duan. Effect of Rock Type on Dynamic Radial-flow Sedimentation Characteristics of High Concentration Wastewater from Processing Aggregate System of Hydropower Project[J]. Journal of Yangtze River Scientific Research Institute, 2023, 40(2): 75-80.

[1]	裴书锋, 郝文锋, 樊义林, 陈浩, 李文涛. 大型水利水电工程锚固系统运行状况分析[J]. 长江科学院院报, 2024, 41(2): 142-150.
[2]	朱杰兵, 吕思清, 汪斌, 祝永锁. 隧道突涌水灾害缩尺物理模型试验研究综述[J]. 长江科学院院报, 2024, 41(1): 98-106.
[3]	任大春, 王亚军, 段杭. 水利水电工程锚固支护监测布置优化分析[J]. 长江科学院院报, 2022, 39(6): 50-55.
[4]	柴朝晖, 王茜, 渠庚, 黄卫东. 长江口徐六泾节点段河槽稳定性及其影响因素[J]. 长江科学院院报, 2022, 39(1): 10-15.
[5]	吴新霞, 胡英国, 刘美山, 赵根, 杨招伟. 水利水电工程爆破技术研究进展[J]. 长江科学院院报, 2021, 38(10): 112-120.
[6]	石妍, 李家正, 董芸, 周世华, 林育强, 陈霞. 水工混凝土矿物掺和料的开发与应用研究综述[J]. 长江科学院院报, 2021, 38(10): 148-155.
[7]	吴越, 杨校礼, 李昱, 胡成, 杨林. 弧形短导航墙对船闸下游引航道内水流结构的影响[J]. 长江科学院院报, 2020, 37(6): 81-84,93.
[8]	宋崔蓉, 李正兵, 张引. 高陡边坡卸荷岩体群锚效应试验研究[J]. 长江科学院院报, 2020, 37(10): 117-124.
[9]	庄玮,鲁程鹏,朱宣毓,李慧敏,王苏婉. 黏土透镜体影响潜流交换的试验研究[J]. 长江科学院院报, 2019, 36(8): 49-54.
[10]	陈昂, 吴淼, 王鹏远, 温静雅, 李慧, 吴赛男. 中国水电工程生态流量实践主要问题与发展方向[J]. 长江科学院院报, 2019, 36(7): 33-40.
[11]	罗菲, 任光明, 李惠民, 李源亮. 四川省道S216沿线滑坡、崩塌发育规律[J]. 长江科学院院报, 2019, 36(6): 37-41.
[12]	张昕健,渠庚,范北林,朱勇辉. 溃堤洪水与堤后冲刷研究综述及展望[J]. 长江科学院院报, 2019, 36(4): 9-12,38.
[13]	周剑, 雷畅, 郑强, 魏鹏帅, 丁高俊, 卞小草. 基于灰度理论QFD的水电工程施工管理系统研发[J]. 长江科学院院报, 2019, 36(12): 151-156.
[14]	张杨, 周黎明, 肖国强. 堤防隐患探测中的探地雷达波场特征分析与应用[J]. 长江科学院院报, 2019, 36(10): 151-156.
[15]	黄国兵. 大型水利水电工程施工水力控制及灾害预测关键技术[J]. 长江科学院院报, 2018, 35(7): 1-8.

岩性对砂石加工高浓度废水动态辐流沉降特性的影响

Effect of Rock Type on Dynamic Radial-flow Sedimentation Characteristics of High Concentration Wastewater from Processing Aggregate System of Hydropower Project

PDF

可视化

摘要/Abstract

引用本文

使用本文

相关文章 15

编辑推荐

Metrics

本文评价