在折流式厌氧反应器(Anaerobic Baffled Reactor,ABR)不同进水管悬空高度和不同进水流量组合的工况下,利用激光粒子图像测速技术(particle image velocimetry,PIV)对ABR的第一格室液相流态进行了研究,测得反应器内降流区和升流区关键截面的流场数据,获得了液相速度和涡量强度与悬空高度的关系曲线;同时研究了相关流场特征,包括流线图谱和涡量场。结果表明:对于ABR的第一格室,合理的进水管悬空高度可以保证良好的进水流态,促使ABR涡量面积分布均匀,有效防止局部沟流和液相死区,确保ABR高效稳定运行。根据试验分析结果,提出了设计时可供参考的进水管悬空高度的取值范围:流量在0.018～0.270 m3/h时,悬空高度的取值范围为230～530 mm;流量在0.558～0.846 m3/h时,悬空高度的取值为530 mm。
Abstract
The flow pattern of liquid phase in the first cell of anaerobic baffled reactor(ABR) was studied in association with laser particle image velocimetry(PIV) under the combined conditions of different inlet flow rates and suspension heights of inlet pipe of the ABR.Flow field data at key section in downward flow area and upward flow area of the reactor were obtained, and the curves of velocity of liquid phase and vorticity intensity vs. suspension height were acquired. Meanwhile, characteristics of relevant flow fields were obtained, including streamline pattern and vorticity field. Results revealed that reasonable suspension height of water inlet pipe was important for the first cell of ABR, for it could ensure good flow pattern, uniform distribution of ABR vortex area, effective prevention of local channel flow and dead zone at liquid phase and stable operation of ABR. According to the experimental results, we suggest the range of suspension height of inlet pipe between 230-530 mm when flow rate is in the range of0.018-0.270 m3/h , and 530 mm when flow rate is in the range of0.558-0.846 m3/h.
关键词
折流式厌氧反应器 /
液相流态 /
粒子图像测速技术 /
竖向进水管布置 /
悬空高度
Key words
anaerobic baffled reactor /
flow pattern of fluid phase /
particle image velocimetry /
layout of vertical inlet pipe /
suspension height
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
[1] 周冬卉,吴时强,祝 龙,等.折流式厌氧反应器水力特性分析[J].水利水运工程学报,2015,37(4):37-42.
[2] 许 明,冯 骞,刘伟京,等.ABR反应器的结构参数对流动及混合特性的影响[J].环境科学研究,2014,27(7):758-762.
[3] 徐存东,杨 柯,肖 璐,等.竖向进水管布置对泵站进水流态的影响模拟[J].灌溉机械工程学报,2012,30(1):40-45.
[4] 张寿通,郭海燕,费庆志,等.斜板式ABR水力特性及生活污水的处理[J].环境化学,2009,28(4):492-496.
[5] VAN LIER J B,VAN DER ZEE F P, TAN N C G ,et al.Advances in High-rate Anaerobic Treatment Staging of Reactor Sysytems[J].Water Scienceand Technology,2001,44(8):15-25.
[6] HOLT C J,MATTHEW R G S,TERZIS E.A Comparative Study Using the Anaerobic Baffled Reactor to Treat a Phenolic Wastewater[C]∥Proceedings of the 8th IAWQ International Conference on Anaerobic Digestion.Sendai,Japan,May 25-29,1997,8(2):40-47.
[7] ALETTE A M.Treatment of Dilute Wastes Using an Anaerobic Baffled Reactor:Effect of Low Temperate[J].Water Reasearch,2000,34(15):3867-3875.
[8] 耿亚鸽,张 翔,张浩勤,等.ABR反应器工程设计的技术探讨[J].水处理技术,2009,35(2):103-107.
[9] 马玲珑,唐艳葵,张寒冰.折流式厌氧反应器的设计[J].广西大学学报(自然科学版),2008,33(6):378-380.
[10]MONTANTE G,PAGLIANTIMAGELLI A,MAGELLI F.Experimen-Talanalysis and Computational Modeling of Gas-Liq-Uidstirred Vvessels[J].Chemical Engineering Research and Design,2007,85(5):647-653.
[11]SAITO T,SAKAKIBARA K,MIYANMOTO Y,et al.A Study of Surfactant Effects on the Liquid-Phase Motion Aro-und a Zigzagging-Ascent Bubble Using a Recursive Cross-Correlation PIV[J].Chemical Engineering Journal,2010,158(1):39-50.
[12]CHENG Wen, MURAI Y, ISHIKAWA M, et al.An Algorithm for Estimating Liquid Flow Field from PTV Measurement Data of Bubble Motion[J].Transactions of the Visualization Society of Japan,2004,23(11):107-114.
[13]UNADKAT H,RIDLLY C D,HARGRAVE G K,et al.Application of Fluorescent PIV and Digital Image Analysis to Measure Turbulence Properties of Solid-Liquid Stirred Suspensions[J].Chemical Engineering Research and Design,2009,87(4):573-586.
[14]杨小林,杨开明,张秉斌,等.折板絮凝池流场的粒子图像测速试验研究[J].环境污染与防治,2008,30(12):47-49.
[15]AJAY K P.Particle Image Velocimetry[J].Current Science,2000,79(1):51-60.
[16]阮 驰,孙传东,白永林,等.水流场PIV测试系统示踪粒子特性研究[J].试验流体力学,2006,20(2):72-77.
[17]王菊红,郭亚兵,胡钰贤.氧化沟弯道流场的模拟与改进[J].能源与环境,2009,(6):10-12.
[18]PEVERE A,GUIBAUD G,VAN HULLEBUSCH E D,et al.Effect of Na＋ and Ca2+ on the Aggregation Properties of Sieved Anaerobic Granular Sludge[J].Colloids and Surfaces,2007,306(1/2/3):142-149.
[19]PIRES E C,HANISCH W S,ANDRADE M A N.An Original Procedure for Physical Simulation of Upflow Anaerobic Sludge Blanket Reactors [J].Bioprocess and Biosystems Engineering,2000,23(4):389-395.
基金
四川省科技支撑计划项目(2014GZ0132);自贡市科技局重点项目(2013X12);四川理工学院创新基金项目(Y2016011)
PDF(4022 KB)
